豌豆蛋白质提取工艺优化及其乳化性和起泡性研究

doi:10.14088/j.cnki.issn0439-8114.2021.08.028

湖北农业科学 ›› 2021, Vol. 60 ›› Issue (8): 134-139.doi: 10.14088/j.cnki.issn0439-8114.2021.08.028

豌豆蛋白质提取工艺优化及其乳化性和起泡性研究

戴媛, 冷进松, 陆红佳

重庆文理学院园林与生命科学学院/特色植物研究院,重庆 402160

收稿日期:2020-06-05 发布日期:2021-05-07
作者简介:戴媛（1979-）,女,吉林永吉人,讲师,博士,主要从事食品营养学研究,（电话）13578762542（电子信箱）448343132@qq.com。
基金资助:
重庆市教委科学技术研究项目（KJQN201901336）; 重庆文理学院校级科研课题引进人才专项（2017RLX37）

Study on process optimization for the extraction of pea protein and its emulsification and foaming activity

DAI Yuan, LENG Jin-song, LU Hong-jia

College of Landscape Architecture and Life Science/Institute of Special Plants, Chongqing University of Arts and Sciences,Chongqing 402160,China

Received:2020-06-05 Published:2021-05-07

摘要/Abstract

摘要： 以干豌豆（Pisum sativum Linn）作为研究对象,研磨成粉,水作为溶剂提取豌豆粉中的蛋白质,采用响应面法优化提取工艺条件并测定提取产物的乳化性和起泡性。在试验研究范围内,最佳提取工艺条件为料液比为1∶30（g∶mL）,酶选择碱性蛋白酶,提取时间为50 min,超声波功率为150 W。在此工艺条件下,豌豆蛋白质提取率高达95.64%。其乳化性和起泡性测定结果表明,乳化活性11.27 mL/g,乳化稳定性36.96 min,起泡活性86.25%,泡沫稳定性33.33%。因此,优化的提取工艺合理、可行,豌豆蛋白质具有较好的乳化活性和乳化稳定性以及较好的起泡活性和泡沫稳定性。

关键词: 豌豆（Pisum sativum Linn）蛋白质, 提取工艺, 响应面法, 乳化性, 起泡性

Abstract: Dry peas were used as research objects, which was ground into powder, and water was used as solvent to extract protein from pea flour. The extraction conditions were optimized using response surface analysis and the emulsification and foaming activity of the extracted products was determined. The results of the optimum extraction conditions within the scope of experimental research were as follows, the ratio of raw material to water 1∶30（g∶mL）, the type of enzyme alkali protease, extraction time 50 minutes, ultrasonic power 150 W. Under these conditions, the extraction rate of pea protein was up to 95.64%. The results of emulsification and foaming activity were as follows, emulsion activity 11.27 mL/g, emulsion stability 36.96 min, foaming activity 86.25%, foam stability 33.33%. Therefore, the optimization of pea protein extraction process technology was reasonable and feasible, and pea protein has stronger emulsification activity and emulsification stability, as well as stronger foaming activity and foam stability.

Key words: pea（Pisum sativum Linn）protein, extraction process, response surface analysis, emulsification activity, foaming activity

中图分类号:

戴媛, 冷进松, 陆红佳. 豌豆蛋白质提取工艺优化及其乳化性和起泡性研究[J]. 湖北农业科学, 2021, 60(8): 134-139.

DAI Yuan, LENG Jin-song, LU Hong-jia. Study on process optimization for the extraction of pea protein and its emulsification and foaming activity[J]. HUBEI AGRICULTURAL SCIENCES, 2021, 60(8): 134-139.

参考文献

[1] 梁晗妮,唐传核. 豌豆蛋白的功能特性研究[J]. 现代食品科技,2012,28(12):1639-1644.
[2] 程萌,齐军茹,曹静. 水溶性豌豆多糖的提取及性能研究[J]. 中国粮油学报,2017,32(10):54-59.
[3] 薛园园. 豌豆蛋白的酶水解及其产物抗氧化性能研究[D].郑州:河南工业大学,2011.
[4] 胡婷婷. 酶改性豌豆蛋白功能特性研究 [D]. 郑州:河南工业大学,2012.
[5] 李宝艳,万端极. 超滤膜法制备豌豆蛋白的工艺[J]. 食品研究与开发,2010,31(10):75-77.
[6] 杨希娟,党斌,吴昆仑,等. 青稞蛋白的超声波辅助提取工艺及其功能特性研究[J]. 中国食品学报,2013,13(6):48-56.
[7] 张煜,王建英,王晶妍. 硫酸铵盐析法分级分离大豆酸沉蛋白[J]. 河南师范大学学报(自然科学版) ,2011,39(6):99-100.
[8] 张秋萍,田亚平. 双酶法酶解豌豆蛋白制备高抗氧化多肽的研究[J]. 天然产物研究与开发,2013, 25(4):519-524.
[9] GB/T 5009.3—2016,食品安全国家标准食品中水分的测定[S].
[10] GB/T 5009.5—2016,食品安全国家标准食品中蛋白质的测定[S].
[11] 柳荫,吴凤智,陈龙,等. 考马斯亮蓝法测定核桃水溶性蛋白含量的研究[J]. 中国酿造, 2013,32(13):131-133.
[12] 邓丽莉,潘晓倩,生吉萍,等. 考马斯亮蓝法测定苹果组织微量可溶性蛋白含量的条件优化[J]. 食品科学,2012,33(24):185-189.
[13] SHAH N N, UMESH K V, SINGHAL R S.Hydrophobically modified pea proteins: Synthesis, characterization and evaluation as emulsifiers in eggless cake[J]. Journal of food engineering, 2019, 255: 15-23.
[14] CHEN M, LU J, LIU F, et al.Study on the emulsifying stability and interfacial adsorption of pea proteins[J]. Food hydrocolloids, 2019, 88: 247-255.
[15] XIONG T, XIONG W, GE M, et al.Effect of high intensity ultrasound on structure and foaming properties of pea protein isolate[J]. Food research international, 2018, 109: 260-267.
[16] PILLAI P K S, STONE A K, GUO Q, et al. Effect of alkaline de-esterified pectin on the complex coacervation with pea protein isolate under different mixing conditions[J]. Food chemistry, 2019, 284: 227-235.
[17] CHAO D F, JUNG S, ALUKO R E.Physicochemical and functional properties of high pressure-treated isolated pea protein[J]. Innovative food science and emerging technologies, 2018, 45: 179-185.
[18] KADAM S U, ÁLVAREZ C, TIWARI B K, et al.Extraction and characterization of protein from Irish brown seaweed Ascophyllum nodosum[J]. Food research international, 2017, 99: 1021-1027.
[19] FEYZI S, MILANI E, GOLIMOVAHHED Q A.Grass pea (Lathyrus sativus L.) protein isolate:The effect of extraction optimization and drying methods on the structure and functional properties[J]. Food hydrocolloids, 2018, 74: 187-196.
[20] MCCARTHY N A, KENNEDY D, HOGAN S A, et al.Emulsification properties of pea protein isolate using homogenization, microfluidization and ultrasonication[J]. Food research international, 2016, 89: 415-421.
[21] 张晓云,谢玲燕,季明敏,等. 超声波辅助碱法提取芡实蛋白工艺[J]. 食品研究与开发,2012,33(11):96-99.
[22] CUI H, PAN H W, WANG P H, et al.Essential oils from Carex meyeriana Kunth: Optimization of hydrodistillation extraction by response surface methodology and evaluation of its antioxidant and antimicrobial activities[J]. Industrial crops and products, 2018, 124: 669-676.
[23] GEERTS M E J, NIKIFORIDIS C V, GOOT A J, et al. Protein nativity explains emulsifying properties of aqueous extracted protein components from yellow pea[J]. Food structure,2017,14:104-111.

豌豆蛋白质提取工艺优化及其乳化性和起泡性研究

Study on process optimization for the extraction of pea protein and its emulsification and foaming activity

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨敏, 奚军伟. 黑藜麦多糖超声辅助提取工艺及其抗氧化活性、稳定性研究[J]. 湖北农业科学, 2023, 62(8): 160-166.
[2]	黎强, 周颖, 卢森华. 响应面法优化消瘤藤总黄酮提取工艺及其抗氧化活性研究[J]. 湖北农业科学, 2023, 62(8): 167-174.
[3]	杨敏, 奚军伟. 厚朴中总鞣质提纯工艺及抗菌活性研究[J]. 湖北农业科学, 2023, 62(6): 129-134.
[4]	王雨茹, 穆文静, 梁亮金, 赵忠丽, 敖恩宝力格. 赤瓟块茎淀粉的提取及理化特性研究[J]. 湖北农业科学, 2023, 62(4): 151-155.
[5]	郑新燕, 赵丹, 王木兰, 陈朝琼. FeCl₃改性沸石制备条件优化及磷吸附机制研究[J]. 湖北农业科学, 2023, 62(12): 63-68.
[6]	付佳乐, 耿直, 陈革豫. 微波辅助低共熔溶剂提取葡萄果渣中原花青素及其稳定性研究[J]. 湖北农业科学, 2023, 62(12): 145-150.
[7]	张春艳, 李贺, 胡畔. 响应面法优化榆黄蘑熟料袋栽菌丝体培养条件[J]. 湖北农业科学, 2023, 62(11): 125-130.
[8]	王瑞, 谢正林, 许俊齐, 林玉文, 吴梦雅. 大球盖菇即食产品加工工艺及安全性评价[J]. 湖北农业科学, 2023, 62(11): 137-142.
[9]	赵腾飞, 贺苏, 王道飞, 李晚成, 应晓国, 马路凯, 邓尚贵. 大黄鱼油提取工艺优化及品质分析[J]. 湖北农业科学, 2023, 62(1): 145-151.
[10]	穆开朗, 程昆木, 王锦, 陈嘉悦. 响应面法优化超声乙醇提取南五味子藤茎中木脂素工艺[J]. 湖北农业科学, 2022, 61(8): 109-114.
[11]	李祯, 侯党社, 张娟, 任小赛. 八角茴香精油的超临界萃取工艺研究[J]. 湖北农业科学, 2022, 61(6): 127-130.
[12]	刘金花, 黄敏, 马家宝, 宾彬, 唐爱存. 参杞强精颗粒制备工艺优化及质量标准的建立[J]. 湖北农业科学, 2022, 61(4): 141-144.
[13]	张雪莲, 刘宇飞, 赵劲松. 响应面法优化湖北麦冬多糖提取工艺及其复合饮料研制[J]. 湖北农业科学, 2022, 61(22): 133-138.
[14]	吴永玲, 魏景, 孟银凤, 李俊伟. 蛇床子中总黄酮最佳提取工艺优化及杀虫抑菌活性研究[J]. 湖北农业科学, 2022, 61(21): 73-78.
[15]	林翠英, 詹源菲, 郝二伟, 陈仪新, 范丽丽. 响应面法优化金花橙皮果脯的加工工艺研究[J]. 湖北农业科学, 2022, 61(20): 127-132.