响应面法优化ZTC1+1Ⅱ型澄清剂对三七茎叶皂苷提取液的除杂工艺

doi:10.14088/j.cnki.issn0439-8114.2020.20.034

湖北农业科学 ›› 2020, Vol. 59 ›› Issue (20): 150-154.doi: 10.14088/j.cnki.issn0439-8114.2020.20.034

响应面法优化ZTC1+1Ⅱ型澄清剂对三七茎叶皂苷提取液的除杂工艺

秦枫^1,2, 李金贵², 朱善元¹, 王红昀¹, 王安平¹, 吴双¹

1.江苏农牧科技职业学院/江苏省兽用生物制药高技术研究重点实验室,江苏泰州 225300;
2.扬州大学兽医学院,江苏扬州 225009

收稿日期:2020-01-08 出版日期:2020-10-25 发布日期:2020-12-04
通讯作者: 朱善元(1967-),男,江苏泰州人,教授,博士,主要从事生物技术的研究,(电话)0523-86158001(电子信箱)jstzzsy@126.com。
作者简介:秦枫(1979-),女,山东烟台人,在读博士研究生,副教授,主要从事天然药物研发,(电话)13961041602(电子信箱)qinancy922@163.com。
基金资助:
国家自然科学基金青年科学基金项目(31702286);江苏高校“青蓝工程”资助项目(00000217008);江苏农牧科技职业学院“凤凰人才工程”项目(10434014001)

Optimization for purifying technologyof the leaves and steams of Panax notoginseng saponins extract with ZTC1+1 II clarifier by response surface method

QIN Feng^1,2, LI Jin-gui², ZHU Shan-yuan¹, WANG Hong-yun¹, WANG An-ping¹, WU Shuang¹

1. Jiangsu Agri-animal Husbandry Vocational College/Jiangsu Provincial Key Laboratory of Veterinary Bio-pharmaceutical High-tech Research,Taizhou 225300,Jiangsu,China;
2. College of Veterinary Medicine,Yangzhou University,Yangzhou 225009,Jiangsu,China

Received:2020-01-08 Online:2020-10-25 Published:2020-12-04

摘要/Abstract

摘要： 为确定ZTC1+1Ⅱ型天然澄清剂用于三七(Panax notoginseng)茎叶皂苷提取液除杂的最佳工艺,在单因素分析的基础上,以药物质量浓度、澄清剂用量、作用温度为自变量,以皂苷含量和固形物去除率作为评价指标,建立三因素三水平的Design-Expert响应面分析方法。结果表明,最佳除杂工艺为药液质量浓度(生药质量与皂苷提取液体积之比)为0.19 g/mL,ZTC1+1Ⅱ型天然澄清剂2组分加入顺序为先B组分后A组分,澄清剂B组分和A组分加入量分别为10%、5%药液体积,作用温度为40 ℃。在此工艺条件下进行三七茎叶皂苷提取液除杂工艺的优化,得出固形物去除率为28.40%,皂苷保留率为92.22%,其相对标准偏差(RSD)分别为1.74%和0.56%,重现性较好,验证了该模型的有效性。

关键词: 三七(Panax notoginseng)茎叶, ZTC1+1Ⅱ型澄清剂, 皂苷含量, 固形物去除率, 响应面法

Abstract: In order to determine the ZTC1+1 II type natural clarifying agent used for notoginseng (Panax notoginseng) leaves and steams glycosides extract the best technology of removing impurity,on the basis of single factor analysis,the concentration of drug quality,clarifying agent dosage,temperature is the independent variable,saponin content and solids removal rate as evaluation index,establishing three factors and three levels of Design- Expert response surface analysis method.The results show that the best process of Panax notoginseng leaves and steamspurificationis as followsThe mass concentration of liquid is0.19 g/mL,the order of ZTC1+1 II natural clarifier is first part A and after part B,the dosage of clarifiers B and A are 10% and 5% volume of the extract,respectively,and acting temperature is 40.Under this technological condition,the removal process of stem and leaf of Panax notoginseng is optimized,and the solid removal rate is 28.40%,the saponin retention rate is 92.22%,and the RSD is 1.74% and 0.56%,respectively.The repeatability is good,which verified the validity of the model.

Key words: stems and leaves of Panax notoginseng, ZTC1+1 II natural clarifier, saponins content, solid removal rate, response surface design

中图分类号:

S853

秦枫, 李金贵, 朱善元, 王红昀, 王安平, 吴双. 响应面法优化ZTC1+1Ⅱ型澄清剂对三七茎叶皂苷提取液的除杂工艺[J]. 湖北农业科学, 2020, 59(20): 150-154.

QIN Feng, LI Jin-gui, ZHU Shan-yuan, WANG Hong-yun, WANG An-ping, WU Shuang. Optimization for purifying technologyof the leaves and steams of Panax notoginseng saponins extract with ZTC1+1 II clarifier by response surface method[J]. HUBEI AGRICULTURAL SCIENCES, 2020, 59(20): 150-154.

参考文献

[1] 陈双,刘春莹,王亚芳,等.从三七茎叶皂苷中分离纯化人参皂苷C-Mx1和Rb3[J].大连工业大学学报,2017,36(4):255-259.
[2] 张兰兰,高文远,周水平,等.三七叶、人参叶和西洋参叶皂苷类成分的研究(英文)[J].天然产物研究与开发,2011,23(6):1064-1068.
[3] GUO X J,ZHANG X L,FENG J T,et al.Purification of saponins from leaves of Panax notoginseng using preparative two-dimensional reversed-phase liquid chromatography/hydrophilic interaction chromatography[J].Anal Bloanal Chem,2013,405(10):3413-3421.
[4] WANG M,ZHANG X J,LIU F,et al.Saponins isolated from the leaves of Panax notoginseng protect against alcoholic liver injury via inhibiting ethanol-induced oxidative stress and gut-derived endotoxin-mediated inflammation[J].J Funct Foods,2015,19:214-224.
[5] CHEN G L,LI H J,ZHAO Y,et al.Saponins from stems and leaves of Panax ginseng prevent obesity via regulating thermogenesis,lipogenesis and lipolysis in high-fat diet-induced obese C57BL/6 mice[J].Food Chem Toxicol,2017,106:393-403.
[6] ZHANG Y C,ZHANG J X,LIU C M,et al.Extraction,isolation,and aromatase inhibitory evaluation of low-polar ginsenosides from Panax ginseng leaves[J].J Chromatogr A,2017,1483:20-29.
[7] 孙双凤,余林.几种天然澄清剂在中药水提液精制中的应用研究[J].石化技术,2016,23(9):43.
[8] 张萍,吴月国,刘骅.ZTC1+1-Ⅱ澄清剂用于中药水提液澄清[J].中国中药杂志,2007,32(2):113-115.
[9] 潘育方,陈丽兰,刘庆堂.壳聚糖对三七茎叶水煮液的絮凝效果考察[J].广东药学,2001,11(6):27-29.
[10] 陈敬,温庆果,刘英慧,等.ZTC1+1-Ⅱ型澄清剂应用于莲子心提取液的除杂工艺研究[J].中南药学,2010,8(12):908-912.
[11] 赵丽,朱善元,黄文强,等.田七须根总皂苷的提取工艺研究[J].黑龙江畜牧兽医,2016(5):160-161,166.
[12] 陈敬,温庆果,刘韶,等.正交设计与响应面法优化壳聚糖对莲子心提取液除杂工艺对比研究[J].中草药,2012,43(11):2183-2188.
[13] 郭朝晖,梁卿,刘霞,等.Ⅱ型ZTC1+1天然澄清剂在黄芪多糖提纯中的应用[J].时珍国医国药,2005,16(9):876-877.
[14] 高静,刘培勋,龙伟.Ⅱ型 ZTC1+1天然澄清剂精制仙鹤复方总糖的研究[J].中国新药杂志,2008(15):1335-1338.
[15] BOX G E P,WILSON K B.On the experimental attainment of opti-mum conditions[J].Breakth Statist,1992,270-310.
[16] MASON R L,GUNST R F,HESS J L.Statistical design and analysis of experiments with applications to engineering and science[M].Second Edition.USA,New York:John Wiley and Sons publication,2003.
[17] MUTHUKUMAR V,RAJESH N,VENKATASAMY R,et al.Math-ematical modeling for radial overcut on electrical discharge ma-chining of incoloy 800 by response surface methodology[J].Proc Mat Sci,2014,6:1674-1682.
[18] RUQAYYAHA TID,JAMAL P,ALAM M Z,et al.Application of re-sponse surface methodology for protein enrichment of cassava peel as animal feed by the white-rot fungus Panus tigrinus M609RQY[J].Food hydrocoll,2014,42(2):298-303.
[19] 王冬东,张辉靠,孙程,等.Box-Behnken响应面法优化水溶性壳聚糖对黄莪凝胶水提液的除杂工艺[J].中国药房,2017,28(28):3987-3991.
[20] 万丹娜,饶倩如,俞梦莹,等.Box-Behnken设计-响应面法优化山楂的醇沉工艺[J].中国药房,2018,29(15):2078-2081.
[21] 王柏强,刘福,何效平,等.ZTC1+1-Ⅱ型澄清剂用于紫苏叶提取液的澄清工艺研究[J].中南药学,2016,14(5):501-504.
[22] 张志信,张仕秀.明胶澄清三七茎叶水提取液[J].文山师范高等专科学校学报,2007,20(3):108-110.
[23] 李维莉,马银海,张亚平,等.无机陶瓷膜-树脂联用技术纯化三七叶苷的工艺研究[J].中药材,2009,32(6):980-982.

响应面法优化ZTC1+1Ⅱ型澄清剂对三七茎叶皂苷提取液的除杂工艺

Optimization for purifying technologyof the leaves and steams of Panax notoginseng saponins extract with ZTC1+1 II clarifier by response surface method

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	黎强, 周颖, 卢森华. 响应面法优化消瘤藤总黄酮提取工艺及其抗氧化活性研究[J]. 湖北农业科学, 2023, 62(8): 167-174.
[2]	杨敏, 奚军伟. 厚朴中总鞣质提纯工艺及抗菌活性研究[J]. 湖北农业科学, 2023, 62(6): 129-134.
[3]	郑新燕, 赵丹, 王木兰, 陈朝琼. FeCl₃改性沸石制备条件优化及磷吸附机制研究[J]. 湖北农业科学, 2023, 62(12): 63-68.
[4]	张春艳, 李贺, 胡畔. 响应面法优化榆黄蘑熟料袋栽菌丝体培养条件[J]. 湖北农业科学, 2023, 62(11): 125-130.
[5]	王瑞, 谢正林, 许俊齐, 林玉文, 吴梦雅. 大球盖菇即食产品加工工艺及安全性评价[J]. 湖北农业科学, 2023, 62(11): 137-142.
[6]	赵腾飞, 贺苏, 王道飞, 李晚成, 应晓国, 马路凯, 邓尚贵. 大黄鱼油提取工艺优化及品质分析[J]. 湖北农业科学, 2023, 62(1): 145-151.
[7]	穆开朗, 程昆木, 王锦, 陈嘉悦. 响应面法优化超声乙醇提取南五味子藤茎中木脂素工艺[J]. 湖北农业科学, 2022, 61(8): 109-114.
[8]	李祯, 侯党社, 张娟, 任小赛. 八角茴香精油的超临界萃取工艺研究[J]. 湖北农业科学, 2022, 61(6): 127-130.
[9]	吴永玲, 魏景, 孟银凤, 李俊伟. 蛇床子中总黄酮最佳提取工艺优化及杀虫抑菌活性研究[J]. 湖北农业科学, 2022, 61(21): 73-78.
[10]	林翠英, 詹源菲, 郝二伟, 陈仪新, 范丽丽. 响应面法优化金花橙皮果脯的加工工艺研究[J]. 湖北农业科学, 2022, 61(20): 127-132.
[11]	郑佳俐, 王文成, 郭欣, 郭萌. 复合天然抗氧化剂在贡糖中的抗氧化效果研究[J]. 湖北农业科学, 2022, 61(16): 142-146.
[12]	陈芳, 温艳, 姜小帆. 响应面法优化超声辅助提取灵芝黄酮工艺研究[J]. 湖北农业科学, 2022, 61(14): 113-118.
[13]	樊金山, 曹正, 黄小忠, 谢春芹, 曹淼, 张宇, 陈岑. 基于模糊综合评判法的银耳红枣猪肉香肠制作工艺研究[J]. 湖北农业科学, 2022, 61(14): 124-130.
[14]	张雪玲, 廉升, 齐淑岚, 郭怡怡, 陈家巍. 基于响应面分析法优化党参多糖提取工艺[J]. 湖北农业科学, 2022, 61(12): 120-123.
[15]	戴媛, 冷进松, 陆红佳. 豌豆蛋白质提取工艺优化及其乳化性和起泡性研究[J]. 湖北农业科学, 2021, 60(8): 134-139.